MANUEL D'ENTRETIEN POUR VTT

MODELS COVERED:

YFM350X Warrior (1987-2004) YFM350S Raptor (2004-2013)

This Yamaha Warrior ATV manual is 480 pages.

QUICK REFERENCE GUIDE

CHAPTER ONE / GENERAL INFORMATION

CHAPTER TWO / TROUBLESHOOTING

CHAPTER THREE / LUBRICATION, MAINTENANCE AND TUNE-UP
Pre-ride checklist / Service maintenance intervals schedule / Engine lubrication / / Engine oil and filter change / Periodic lubrication / Control cable lubrication / Drive chain cleaning adjustment lubrication / Periodic maintenance / Non-scheduled maintenance / Parking brake adjustment / Speed limiter / Air filter / Toe-in adjustment / Tune-up / Valve clearance / Cylinder compression test check / Spark plug / Ignition timing / Pilot air screw adjustment / Idle speed adjustment / Storage / Specifications

CHAPTER FOUR / ENGINE TOP END
Engine principles / Decompression cam / Chain guides / Cylinder / Pistons and piston rings / Specifications

CHAPTER FIVE / ENGINE LOWER END
Removal / Installation / Primary drive gear, balancer gears and oil pump drive gear / Oil pump / Oil pipe / Stator and stator housing / Alternator rotor and starter clutch / Crankcase and crankshaft / Recoil starter / Break-in procedure / Specifications

CHAPTER SIX / CLUTCH AND EXTERNAL SHIFT MECHANISM
Clutch cover / Clutch / External shift mechanism / Specifications

CHAPTER SEVEN / TRANSMISSION AND INTERNAL SHIFT MECHANISM
Transmission / reverse system identification / Transmission troubleshooting / Output axle / Counter wheel gear assembly / Reverse gear / Transmission inspection / Forward shift mechanism / Reverse shift mechanism / Reverse shift lever adjustment / Specifications

CHAPTER EIGHT / FUEL AND EXHAUST SYSTEMS
Carburetor operation / Carburetor / Carburetor adjustments / Fuel tank / Air filter air box / Specifications

CHAPTER NINE / ELECTRICAL SYSTEM
Alternator (stator charge coil) / Voltage regulator/rectifier / Capacitor discharge ignition / Ignition coil / Starting system / Starter solenoid / Lighting system / Switches / Reverse switch relay / Starting circuit cut-off relay / Neutral switch relay / Specifications

CHAPTER TEN / FRONT SUSPENSION AND STEERING
Front wheel / Front hub / Shock absorber / Steering knuckle / Handlebar / Steering shaft / Tires and wheels / Specifications

CHAPTER ELEVEN / REAR SUSPENSION
Rear wheels / Rear axle housing / Drive chain / Driven sprocket / Tire changing and tire repairs / Shock absorber / Suspension linkage / Rear swing arm / Specifications

CHAPTER TWELVE / BRAKES
Disc brake / Rear caliper / Brake disc / Brake bleeding / Specifications

CHAPTER THIRTEEN / BODY
Seat / Fuel tank cover / Footpegs / Specifications

CHAPTER FOURTEEN / SUPPLEMENT RAPTOR MODELS

INDEX

COLOR WIRING DIAGRAMS